2 Va. Admin. Code § 5-585-1460

Current through Register Vol. 41, No. 8, December 2, 2024

Section 2VAC5-585-1460 - Manual warewashing, sink compartment requirements

A. Except as specified in subsection C of this section, a sink with at least three compartments shall be provided for manually washing, rinsing, and sanitizing equipment and utensils.^Pf

B. Sink compartments shall be large enough to accommodate immersion of the largest equipment and utensils. If equipment or utensils are too large for the warewashing sink, a warewashing machine or alternative equipment as specified in subsection C of this section shall be used.^Pf

C. Alternative manual warewashing equipment may be used when there are special cleaning needs or constraints and its use is approved. Alternative manual warewashing equipment may include:

1. High-pressure detergent sprayers;

2. Low-pressure or line-pressure spray detergent foamers;

3. Other task-specific cleaning equipment;

4. Brushes or other implements;

5. Two-compartment sinks as specified under subsections D and E of this section; or

6. Receptacles that substitute for the compartments of a multicompartment sink.

D. Before a two-compartment sink is used:

1. The operator shall have its use approved; and

2. The operator shall limit the number of kitchenware items cleaned and sanitized in the two-compartment sink, shall limit warewashing to batch operations for cleaning kitchenware such as between cutting one type of raw meat and another or cleanup at the end of a shift, and shall:

a. Make up the cleaning and sanitizing solutions immediately before use and drain them immediately after use; and

b. Use a detergent-sanitizer to sanitize and apply the detergent-sanitizer in accordance with the manufacturer's label instructions and as specified under 2VAC5-585-1710; or

c. Use a hot water sanitization immersion step as specified under subdivision 3 of 2VAC5-585-1860.

E. A two-compartment sink may not be used for warewashing operations where cleaning and sanitizing solutions are used for a continuous or intermittent flow of kitchenware or tableware in an ongoing warewashing process.

2 Va. Admin. Code § 5-585-1460

Derived from Virginia Register Volume 24, Issue 2, eff. October 16, 2007; Amended, Virginia Register Volume 32, Issue 22, eff. 7/12/2016.

Statutory Authority: § 3.2-5121 of the Code of Virginia.