Section 430 ILCS 45/4 - Chemical Safety Contingency Plans(a) After July 1, 1986, no business shall operate a facility without a written Chemical Safety Contingency Plan unless exempted from this requirement under subsection (f) or otherwise included under the requirements of subsection (g) of this Section. At least one copy of the current plan shall be maintained at the facility at all times. The plan shall be reviewed by the business no less than annually, and changes from the previous year's plan shall be clearly identified, if such changes are necessary.(b) The Chemical Safety Contingency Plan shall, at a minimum, include the following: (1) A listing of the chemical substances that may be released at the facility, including both the chemical names and corresponding trade names, if any, and a brief description of the manner in which the substances are stored and used. This listing is not intended to include substances that are reasonably expected to be innocuous under the circumstances of their use or any release. In the case of mixtures of substances, the business may rely upon labeling in determining the need for listing.(2) Information on the probable nature and routes of any releases of these substances, and the possible causes of any of the releases.(3) The response procedures to be followed at the facility and for notifying local emergency response agencies, including but not limited to on-site alarm systems, on-site evacuation plans, and arrangements made under Section 5 to coordinate emergency services with local police departments, fire departments, hospitals, and other local emergency response agencies.(4) A list of names, addresses, and phone numbers (office and home) of appropriate persons qualified to act as the facility's emergency coordinator and alternate coordinator; if more than 2 persons are listed, the persons must be listed in the order in which they will assume responsibility as alternates.(5) A list of emergency equipment at the facility, such as fire extinguishing systems and decontamination equipment, including the location and description of each item of equipment.(c) No later than July 1, 1986, and whenever the plan is changed, one copy of the current Chemical Safety Contingency Plan for each facility shall be provided by each business to the appropriate local fire, police or other emergency response agency as determined by the local response plan or by agreement. After submission, the plan shall be made available for inspection by the public during normal operating hours. The IEMA may by rule under Section 5 of this Act require the business to provide copies of the Chemical Safety Contingency Plan to additional entities.(d) For each facility, a business shall notify IEMA of compliance with subsection (c) no later than July 15, 1986, and whenever the plan is changed.(e) On an annual basis, the appropriate local response agency may notify a business in writing that a chemical substance, that is not listed in the plan but is present at the facility, must be included within 60 days. In issuing the notice, the local response agency shall consider the quantity, phase (gas, liquid or solid) and relative toxicity of the chemical substance, and the potential for a release to result in acute impacts on human health or the environment. The requirement shall be binding upon the business unless, within 15 days of receipt of the notification, the business submits to the IEMA a written request for reconsideration, including the reasons therefor. In consultation with the Agency, the IEMA shall, within 30 days of the receipt of the request, notify the business and the local response agency in writing regarding the final determination. This final determination shall take effect following the 35th day after receipt by the business of notice of the determination, unless prior to such date the business or the local response agency files a petition for review of the decision under the Administrative Review Law.(f) The IEMA may issue an exemption to a business from the requirements of subsection (a) for any facility that uses, stores, or manufactures any chemical substance in an innocuous amount that is not likely to result in a release that threatens the environment or the public health. An exemption shall be issued only on the basis of an on-site inspection of the facility conducted by the Agency, or upon written certification by the business that is verified by the Agency, and certified to the IEMA after providing 60 days notice to the appropriate local emergency planning committee. If an objection to the exemption is filed by the local emergency planning committee, the IEMA may not further act until the objection is resolved. The IEMA may cancel any exemption at any time by sending written notice to the business that operates the facility. If action is taken to cancel an exemption, the business shall comply with subsection (a) within 90 days.
A business that has been granted an exemption for a facility shall notify the IEMA within 30 days after using, storing, or manufacturing any chemical substance in greater than innocuous amounts.
(g) No business, that has been notified in writing by the IEMA of the applicability of this Act under the last paragraph of the definition of "business" in Section 3, shall operate a facility after 90 days after the receipt of the notification without a written Chemical Safety Contingency Plan. The plan shall, at a minimum, include the following: (1) A listing of those extremely hazardous substances, that are present in an amount in excess of the threshold planning quantity, as defined by the Federal Emergency Planning and Community Right-to-Know Act of 1986, unless the business is a chemical and allied products terminal (SIC 5169) or a petroleum and petroleum products wholesaler/terminal (SIC 5172). For these types of terminal facilities, the listing shall include those chemical substances as required under paragraph (1) of subsection (b), except that the substances that are present at a facility for not more than 14 consecutive days may be listed categorically by USDOT Hazard Class.(2) The information, procedures, and listings as required under paragraphs (2), (3), (4), and (5) of subsection (b). At least one copy of the current plan shall be maintained at each facility at all times, and the plan shall be reviewed by each business no less often than annually. Upon initial preparation, and whenever the plan is changed, one copy of the current plan shall be provided by each business to the appropriate local fire, police, or other emergency response agency. For each facility, a business shall notify IEMA of compliance with this subsection no later than 15 days after the initial 90 day period, and whenever the plan is changed.
P.A. 90-442, eff. 8/16/1997.