Section R315-15-2 - Standards for Used Oil Generators2.1 APPLICABILITY (a) General. Except as provided in paragraphs (a)(1) through (a)(4) of this section, R315-15-2 applies to all used oil generators. A used oil generator is any person, by site, whose act or process produces used oil or whose act first causes used oil to become subject to regulation.(1) Household "do-it-yourselfer" used oil generators. Household "do-it-yourselfer" used oil generators are not subject to regulation under R315-15, except for the prohibitions of R315-15-1.3 and cleanup requirements of R315-15-9.(2) Vessels. Vessels at sea or at port are not subject to R315-15-2. For purposes of R315-15-2, used oil produced on vessels from normal shipboard operations is considered to be generated at the time it is transported ashore. The owner or operator of the vessel and the person(s) removing or accepting used oil from the vessel are co-generators of the used oil and are both responsible for managing the used oil in compliance with R315-15-2 once the used oil is transported ashore. The co-generators may decide among themselves which party will fulfill the requirements of R315-15-2.(3) Diesel fuel. Mixtures of used oil and diesel fuel mixed by the generator of the used oil for use in the generator's own vehicles are not subject to R315-15 once the used oil and diesel fuel have been mixed. Prior to mixing, the used oil fuel is subject to the requirements of R315-15-2.(4) Farmers. Farmers who generate an average of 25 gallons per month or less of used oil from vehicles or machinery used on the farm in a calendar year are not subject to the requirements of R315-15, except for the prohibitions of R315-15-1.3 and cleanup requirements of R315-15-9.(b) Other applicable provisions. Used oil generators who conduct the following activities are subject to the requirements of other applicable provisions of R315-15 as indicated in R315-15.2.1(b)(1) through (5) :(1) Generators who transport used oil, except under the self-transport provisions of R315-15-2.5(a) and (b), shall also comply with R315-15-4.(2)(i) Except as provided in R315-15-2.1(b)(2) (ii), generators who process or re-refine used oil must also comply with R315-15-5.(ii) Generators who perform the following activities are not processors, provided that the used oil is generated onsite and is not being sent offsite to a burner of on- or off-specification used oil fuel.(A) Filtering, cleaning, or otherwise reconditioning used oil before returning it for reuse by the generator;(B) Separating used oil from wastewater generated onsite to make the wastewater acceptable for discharge or reuse in accordance with section 402 or section 307(b) of the Clean Water Act or other applicable Federal or state regulations governing the management or discharge of wastewater;(C) Using oil mist collectors to remove small droplets of used oil from in-plant air to make plant air suitable for continued recirculation;(D) Draining or otherwise removing used oil from materials containing or otherwise contaminated with used oil in order to remove excessive used oil to the extent possible in accordance with R315-15-1.1(c); or(E) Filtering, separating or otherwise reconditioning used oil before burning it in a space heater in accordance with R315-15-2.4.(3) Generators who burn off-specification used oil for energy recovery, shall also comply with R315-15-6.(4) Generators who direct shipments of off-specification used oil from their facility to a used oil burner or first certify that used oil that is to be burned for energy recovery meets the used oil fuel specifications set forth in R315-15-1.2 shall also comply with R315-15-7.(5) Generators who dispose of used oil shall also comply with R315-15-8.2.2 HAZARDOUS WASTE MIXING (a) Mixtures of used oil and hazardous waste shall be managed in accordance with R315-15-1.1(b).(b) The rebuttable presumption for used oil found in R315-15-1.1(b)(1)(ii) applies to used oil managed by generators. Under this rebuttable presumption, used oil containing greater than 1,000 ppm total halogens is presumed to be a hazardous waste and thus shall be managed as hazardous waste and not as used oil unless the presumption is rebutted. However, the rebuttable presumption does not apply to certain metalworking oil or fluids containing chlorinated paraffins, if they are processed through a tolling agreement to reclaim the metalworking oils or fluids, and certain used oils removed from refrigeration units described in R315-15-1.1(b)(1)(ii) (B).2.3 USED OIL STORAGE Used oil generators are subject to all applicable Spill Prevention, Control and Countermeasures, 40 CFR 112, in addition to the requirements of R315-15-2. Used oil generators are also subject to the standards and requirements of R311-200 through R311-209, Underground Storage Tanks, for used oil stored in underground tanks whether or not the used oil exhibits any characteristics of hazardous waste. In addition, used oil generators are subject to the requirements of R315-15-2.
(a) Storage units. Used oil generators shall not store used oil in units other than tanks, containers, or units subject to regulation under R315-7 or R315-8.(b) Condition of units. Containers and aboveground tanks used to store used oil at generator facilities shall be: (1) In good condition, with no severe rusting, apparent structural defects or deterioration; and(3) Tanks and containers for storage of used oil must be closed during storage except when adding or removing used oil.(4) Tanks and containers storage areas shall be managed to prevent releases of used oil to the environment.(c) Labels. (1) Containers and aboveground tanks used to store used oil at generator facilities shall be labeled or marked clearly with the words "Used Oil".(2) Fill pipes used to transfer used oil into underground storage tanks at generator facilities shall be labeled or marked clearly with the words "Used Oil."(d) Response to releases. Upon detection of a release of used oil to the environment not subject to the requirements of Section R311-202-1, which incorporates by reference 40 CFR 280, Subpart F, a generator shall comply with Section R315-15-9.2.4 ON-SITE BURNING On-site burners shall comply with R315-15-6 and, if applicable, shall obtain an Air Quality permit.
(a) Generators may burn used oil in used oil-fired space heaters without a used oil permit provided that: (1) The heater burns only used oil that the owner or operator generates;(2) The heater is designed to have a maximum capacity of not more than 0.5 million Btu per hour;(3) The combustion gases from the heater are vented to the outside ambient air;(4) The generator has knowledge that the used oil has not been mixed with hazardous waste; and(5) The used oil is being legitimately burned to utilize its energy content.(b) Used Oil Collection Center(UOCC). If it is registered as a Used Oil Collection Center as authorized in R315-15-3, the UOCC may burn used oil in used oil fired space heaters without a used oil permit under the provision described in R315-15-2.4(a) provided that the used oil is received from household do-it-yourselfer generators or farmers described in R315-15-2.1(a)(4) or the used oil is received from other generators and has been certified to meet the used oil fuel specifications of R315-15-1.2 by a registered used oil marketer in accordance with R315-15-7.2.5 OFF-SITE SHIPMENTS Except as provided in R315-15-2.5(a) through (c), a generator shall ensure that its used oil is transported only by a transporter who hasobtained a Utah used oil transporter permit and has a current used oil handler certificate issued by the Director and an EPA identification number.
(a) Self-transportation of small amounts to approved collection centers. A generators may transport, without an EPA identification number, a used oil transporter permit, or a current used oil handler certificate, used oil that is generated at the generator's site and used oil collected from household do-it-yourselfers to a used oil collection center provided that:(1) The generator transports the used oil in a vehicle owned by the generator or owned by an employee of the generator;(2) The generator transports no more than 55 gallons of used oil at any time; and(3) The generator transports the used oil to a used oil collection center that is registered or permitted to manage used oil.(b) Self-transportation of small amounts to aggregation points owned by the generator. A generator may transport, without an EPA identification number, a used oil transporter permit, or used oil handler certificate, used oil that is generated at the generator's site to an aggregation point provided that: (1) The generator transports the used oil in a vehicle owned by the generator or owned by an employee of the generator;(2) The generator transports no more than 55 gallons of used oil at any time; and(3) The generator transports the used oil to an aggregation point that is owned, operated, or both by the same generator.(c) Tolling arrangements. Used oil generators may arrange for used oil to be transported by a transporter without an EPA identification number, a used oil transporter permit, or a current used oil handler certificate if the used oil is reclaimed under a contractual agreement under which reclaimed oil is returned by the processor/re-refiner to the generator for use as a lubricant, cutting oil, or coolant. The contract, known as a "tolling arrangement," shall indicate: (1) The type of used oil and the frequency of shipments;(2) That the vehicle used to transport the used oil to the processing/re-refining facility and to deliver recycled used oil back to the generator is owned and operated by the used oil processor/re-refiner; and(3) That reclaimed oil will be returned to the generator.Utah Admin. Code R315-15-2
Amended by Utah State Bulletin Number 2014-21, effective 10/3/2014