Section 3745-15-05 - "De Minimis" air contaminant source exemption[Comment: For dates and availability of non-regulatory government publications, publications of recognized organizations and associations, federal rules, and federal statutory provisions referenced in this rule, see paragraph (BB) of rule 3745-15-01 of the Administrative Code titled "referenced materials."]
(A) For purposes of this rule, the following definitions apply:(1) "Actual emissions" means the amount of emissions an air contaminant source actually emits on a calendar day or calendar year basis, whichever is applicable.(2) "Air contaminant" means particulate matter, dust, fumes, gas, mist, radionuclides, smoke, vapor, or odorous substances, or any combination thereof, but does not include water by itself.(3) "Air contaminant source" or "source" means each separate operation or activity that results or may result in the emission of any air contaminant.(4) "Air pollution control equipment" means control equipment which is not, aside from air pollution control requirements, vital to production of the normal product of the source or to its normal operation. Equipment is vital if the source could not produce its normal product or operate without it.(5) "Hazardous air pollutant" means any pollutant listed pursuant to Section 112(b) of the CAA.(6) "Potential to emit" or "potential emissions" means the amount of emissions of an air contaminant, based on maximum rated capacity, which would be emitted from a source during a twenty-four hour calendar day or calendar year basis, whichever is applicable, if that source were operated without the use of air pollution control equipment unless such control equipment is, aside from air pollution control requirements, necessary for the facility to produce its normal product or is integral to the normal operation of the source. (7) "Similar sources" are the following: (a) Sources for which construction and operation are essentially the same, although, the capacity of each source is not necessarily the same.(b) Sources in which the physical or chemical process occurring in each source is essentially the same.(c) Sources from which essentially the same air pollutants are emitted.(B) Except as provided in paragraphs (C), (D) and (H) of this rule and division (B) of section 3704.011 of the Revised Code, any air contaminant source is exempt from Chapter 3704. of the Revised Code and rules adopted thereunder, unless the potential emissions of any one of the following exceeds ten pounds per day: particulate matter, sulfur dioxide, nitrogen oxides, organic compounds, carbon monoxide, lead or any other air contaminant.(C) The exemption contained in paragraph (B) of this rule shall not apply to a source if any of the following applies:(1) A requirement established under the CAA or regulations adopted under it limits the emissions of an air pollutant from the source to less than ten pounds per day or restricts the operation of the source in a manner equivalent to an emission limit of less than ten pounds per day.(2) The source is subject to an emission limit adopted by the director to achieve and maintain the national ambient air quality standards or a rule adopted by the director to protect public health and welfare limits the emissions from the source to less than ten pounds per day of an air pollutant or restricts the operation of the source in a manner equivalent to an emission limit of less than ten pounds per day.(3) The source emits radionuclides.(4) The source alone or in combination with similar sources at the same facility, would result in potential emissions of any air pollutant in excess of twenty-five tons per year. In determining the total emissions from a group of similar sources, an enforceable permit emission limit shall be used in lieu of the potential to emit for such source or sources.(5) The source emits more than one ton per year of any hazardous air pollutants or combination of hazardous air pollutants.(D) The exemption provided in division (A) of section 3704.011 of the Revised Code does not apply to an air contaminant source having potential emissions greater than ten pounds per day (or one ton per year of one or more hazardous air pollutants) of any air contaminant unless the owner or operator of the source maintains records that are adequate to demonstrate that actual emissions from the source did not exceed ten pounds per day (or one ton per year of one or more hazardous air pollutants) and unless that source is not subject to the limitations specified in paragraph (C) of this rule.(E) In order to verify that actual emissions from a source described in paragraph (D) of this rule complied with the requirements of divisions (A) and (C) of section 3704.011 of the Revised Code during its operations, the owner or operator of the source shall maintain records that show that emissions of any air contaminant from the source did not exceed ten pounds per day on each day the source emitted air contaminants, and that the source in any one year did not emit more than one ton of hazardous air pollutants , and that the emissions from the source, in combination with similar air contaminant sources at the same facility, did not result in potential emissions of any air contaminant from the facility in excess of twenty-five tons during the preceding calendar year. Records consisting of one or more of the following types of information, if applicable, shall be adequate to make that demonstration, so long as the information clearly demonstrates that the owner or operator is operating in accordance with this rule:(1) A narrative description of how the emissions from the source were determined and maintained at or below the daily exemption level, and, for emissions of hazardous air pollutants, at or below the annual exemption level.(2) A description of the air pollution control equipment used on the source and a statement that the source is not capable of operating without that pollution control equipment functioning.(3) If air pollution control equipment is used, a copy of any report of the results of any emission test that was conducted following Ohio EPA approved methods, if applicable, or any other emission evaluation.(4) A description of all production constraints required for the source to comply with the exemption levels.(5) Records of actual operations that demonstrate that the daily and annual emissions from the source were maintained at or below the exemption level by the use of the necessary production constraints or pollution control equipment.(6) A list of all similar sources at the same facility and a statement for each such source of the annual potential emissions. Compliance with paragraph (C)(4) of this rule shall be demonstrated.(7) A summation of the total emissions from each exempt or similar source, a summation of stated potential emissions from all sources identified in paragraph (E)(6) of this rule, and a written certification by the owner or operator that the applicable exemption levels were complied with.(F) Records developed under paragraph (E) of this rule shall be maintained by the owner of the source at a location at the facility for a period of two years following the recording of the information, and provided, upon request, to the director.(G) The owner or operator of such an exempt source not subject to paragraph (E) of this rule, upon the request of the director or the director's authorized representative concerning such source, shall provide information that is adequate to demonstrate that the source qualifies for the exemption.(H) Nothing in this rule shall be construed to exempt any source from requirements of the CAA, including its being considered for purposes of determining whether a facility constitutes a major source or is otherwise regulated under Chapter 3745-77 of the Administrative Code or any requirement to identify insignificant activities and emissions levels in a title V permit application. In addition, this rule does not exempt any source that is a part of a major new source or major modification that would be required to meet any requirements under applicable state or federal regulations.(I) If a source exempt under this rule should at any time exceed the exempt emission levels provided in paragraphs (B) and (D) of this rule, the owner or operator of such source shall immediately submit a written report describing the nature and cause of the exceedance. Upon request by the director, the owner or operator of such source shall submit an application for a permit to install if required by Chapter 3745-31 of the Administrative Code and an application for a permit to operate pursuant to Chapter 3745-77 of the Administrative Code, as applicable.Ohio Admin. Code 3745-15-05
Effective: 2/19/2023
Five Year Review (FYR) Dates: 11/29/2022 and 11/29/2027
Promulgated Under: 119.03
Statutory Authority: 3704.03(E)
Rule Amplifies: 3704.03(F)
Prior Effective Dates: 04/20/1994, 11/18/1994, 02/03/2000, 01/22/2009, 07/20/2015