N.H. Code Admin. R. Env-A 3513.02

Current through Register No. 25, June 20, 2024

Section Env-A 3513.02 - Recordkeeping and Reporting for Small, Medium, and Large HMIWI Units

(a) The owner or operator of a small, medium, or large HMIWI unit shall maintain the following information, for a minimum of 5 years:

(1) Calendar date of each record;

(2) Records of the following data, as applicable:

a. Concentrations of any pollutant listed in Env-A 3505.02(a) or measurements of opacity as determined by the continuous emission monitoring system;

b. HMIWI charge dates, times, and weights and hourly charge rates;

c. Fabric filter inlet temperatures during each minute of operation;

d. Amount and type of dioxin/furan sorbent used during each hour of operation;

e. Amount and type of mercury sorbent used during each hour of operation;

f. Amount and type of hydrogen chloride sorbent used during each hour of operation;

g. Secondary chamber temperatures recorded during each minute of operation;

h. Liquor flow rate to the wet scrubber inlet during each minute of operation;

i. Horsepower or amperage to the wet scrubber during each minute of operation;

j. Pressure drop across the wet scrubber system during each minute of operation;

k. Temperature at the outlet from the wet scrubber during each minute of operation;

l. pH at the inlet to the wet scrubber during each minute of operation;

m. Records indicating use of the bypass stack, including dates, times and durations, and

n. For HMIWI units using an alternative air pollution control device in accordance with Env-A 3511.05(i) and Env-A 3512.02(a)(3), all operating parameter data collected;

(3) Identification of calendar days for which data on emission rates or operating parameters specified pursuant to (2), above, have not been obtained, with an identification of the emission rates or operating parameters not measured, reasons for failure to obtain the data, and a description of corrective actions taken;

(4) Identification of calendar days, times and durations of malfunctions, a description of the malfunction and the corrective action taken;

(5) Identification of calendar days for which data on emission rates or operating parameters pursuant to (2), above, exceeded the applicable limits, with a description of the exceedances, reasons for such exceedances, and a description of corrective action taken;

(6) The results of the initial, annual, and any subsequent performance tests conducted to determine compliance with the emission limits and/or to establish operating parameters, as applicable;

(7) Records showing the names of HMIWI operators who have completed review of the operator qualifications and requirements pursuant to Env-A 3506.01 including the date of the initial review and all subsequent annual reviews;

(8) Records showing the names of the HMIWI operators who have completed the operator training requirements pursuant to Env-A 3506.01, including documentation of training and the dates of the training;

(9) Records showing the names of the HMIWI operators who have met the criteria for qualification pursuant to Env-A 3506.02 and the dates of their qualification; and

(10) Records of calibration of any monitoring devices pursuant to Env-A 3512.02(a)(1), (2) and (3).

(b) All records specified pursuant to (a), above, shall be maintained onsite in either paper copy or computer-readable format, unless an alternative format is approved by the department, pursuant to the procedures set forth in Env-A 205.

(c) The owner or operator of a HMIWI unit shall submit the following information to the department no later than 60 days following the initial performance test with all reports signed by a responsible official:

(1) The initial performance test data recorded pursuant to Env-A 3511.01(a) or 3511.02(a), as applicable;

(2) The values for the site-specific operating parameters established pursuant to Env-A 3511.05(c) or (i), as applicable; and

(3) The waste management plan developed in accordance with Env-A 3509.01.

(d) In accordance with the permitting requirements under Title V of the Act, the owner or operator of a small, medium or large HMIWI unit shall submit a semi-annual report signed by a responsible official that includes the following information:

(1) The values for the site-specific operating parameters established pursuant to Env-A 3511.05(c) or (i), as applicable;

(2) The highest maximum operating parameter and the lowest minimum operating parameter, as applicable, for each operating parameter recorded for the calendar year being reported, pursuant to Env-A 3511.05(c) or (i);

(3) The highest maximum operating parameter and the lowest minimum operating parameter, as applicable for each operating parameter recorded pursuant to Env-A 3511.05(c) or (i) for the calendar year preceding the year being reported in order to provide the departmentwith a summary of the performance of the affected HMIWI unit over a 2-year period;

(4) Any information recorded pursuant to (a)(3) through (a)(5), above, for the calendar year being reported;

(5) Any information recorded pursuant to (a)(3) through (a)(5), above, for the calendar year preceding the year being reported, in order to provide the department with a summary of the performance of the affected HMIWI unit over a 2-year period;

(6) The results of any performance tests, if any such tests were conducted during the reporting period;

(7) A statement that no exceedances occurred during the reporting period, if no exceedances or malfunctions were reported pursuant to (a)(3) through (a)(5), above, for the calendar year being reported; and

(8) Any use of the bypass stack, the duration, reason for malfunction, and corrective action taken.

(e) The owner or operator of a small, medium, or large HMIWI unit shall submit semi-annual reports containing information recorded pursuant to (a)(3) through (a)(5), above, and signed by a responsible official, according to the following schedule:

(1) The initial report shall be submitted no later then 60 days following the initial reporting period;

(2) The first semiannual report shall be submitted within 6 months of submission of the information specified in (b) above; and

(3) Subsequent reports shall be submitted no later than 6 calendar months following the previous report.

N.H. Code Admin. R. Env-A 3513.02

#6938, eff 1-30-99; amd by #7127, eff 10-30-99; ss by #8788, eff 1-5-07