326 Ind. Admin. Code 6.8-2-6

Current through May 29, 2024
Section 326 IAC 6.8-2-6 - BP Products North America, Inc.-Whiting Refinery

Authority: IC 13-14-8; IC 13-17-3-4; IC 13-17-3-11

Affected: IC 13-15; IC 13-17

Sec. 6.

(a) BP Products North America, Inc.-Whiting Refinery in Lake County, source identification number 00453, shall meet the following emission limits:

Source Emission Limits
lbs/MMBtu lbs/hr
CRU, F-101 feed preheater 0.0075 0.536
Stack serving number 1 CRU, F-102A heater 0.0075 0.447
Stack serving number 1 power station, boiler numbers 5, 6, and 7 0.0075 5.924
Stack serving number 11 pipe still furnaces H-101, H-102, H-103, H-104, coke preheaters 0.0075 1.49
Number 11 pipe still, H-1X heater 0.0075 1.863
Number 11 pipe still, H-2 vacuum heater 0.0075 0.335
Number 11 pipe still, H-200 crude charge 0.0075 1.859
Number 11 pipe still, H-3 vacuum heater 0.0075 0.410
Number 11 pipe still, H-300 furnace 0.0075 1.341
Stack serving number 12 pipe still, H-1AS, H-1AN, and H-1B preheaters and H-2 vacuum heater 0.0075 4.918
Each stack serving number 12 pipe still H-1CN crude preheater 0.0075 0.894
Number 12 pipe still, H-1CX crude preheater 0.0075 3.055
Number 2 isomerization, H-1 feed heater furnace 0.0075 1.416
Each stack serving number 3 power station, boiler numbers 1, 2, 3, 4, and 6 0.0075 4.28
Number 3 ultraformer, F-7 furnace 0.0075 0.171
Number 3 ultraformer, H-1 feed heater furnace 0.0075 1.788
Number 3 ultraformer, H-2 feed heater furnace 0.0075 1.378
Stack serving number 4 ultraformer, F-1 ultrafiner furnace F-8A and F-8B reboilers 0.0075 2.936
Number 4 ultraformer, F-2 preheater furnace 0.0075 2.131
Number 4 ultraformer, F-3 number 1 reheat furnace 0.0075 1.803
Stack serving number 4 ultraformer, F-4 number 2 reheat furnace, F-5 number 3 reheat furnace, and F-6 number 4 reheat furnace 0.0075 2.124
Number 4 ultraformer, F-7 furnace 0.0075 0.387
Aromatics recovery unit, F-200A furnace 0.0075 1.859
Aromatics recovery unit, F-200B furnace 0.0075 1.859
Blending oil desulphurization, F-401 furnace 0.0075 0.261
Each stack serving the cat feed hydrotreating unit F-801 A/B and F-801C 0.0075 0.943
Asphalt F-1 heater 0.0075 0.089
Asphalt F-2 Steiglitz Park residual heater 0.0075 0.209
Sulfur recovery unit incinerator 0.0075 0.285
Beavon Stretford tail gas unit (B/S TGU) 0.0075 0.182
DDU WB-301, DDU WB-302 0.0075 1.106
Hydrogen unit B-501 0.0075 2.729
(b) The F-100 marine docks distillate heater shall have the following emission limits:
Source Emission Limits
lbs/MMBtu lbs/hr
(c) BP shall comply with the following emission limits: 0.0075 0.052
Source Emission Limits
Units lbs/hr
Wastewater sludge fluid bed incinerator 0.173 lbs/ton based on 79,000 lbs/hr fluidizing air flow 6.84
FCU 500 1.220 lbs/1,000 lbs coke burned 73.20
FCU 600 1.10 lbs/1,000 lbs coke burned 55.00

(d) Emission limits in subsections (a) and (b) apply to the sum of the filterable (front half) and condensible (back half) particulate matter. The total quantity of particulate matter emissions shall be determined in accordance with 40 CFR 51, Appendix M, Method 201A* for determining filterable matter and 40 CFR 51, Appendix M, Method 202* for determining condensibles. However, if a demonstration is made to the commissioner that excessive temperatures preclude the use of 40 CFR 51, Appendix M, Method 201A*, then the commissioner may allow the use of 40 CFR 60, Appendix A, Method 5* for determining filterable matter emissions, to be used in conjunction with 40 CFR 51, Appendix M, Method 202* for determining condensibles. Alternatives to these methods may be used, but only if they are approved in writing by U.S. EPA prior to the test.

*These documents are incorporated by reference and are available from the Government Printing Office, 732 North Capitol Avenue NW, Washington, D.C. 20401 or are available for review and copying at the Indiana Department of Environmental Management, Office of Air Quality, Indiana Government Center-North, Tenth Floor, 100 North Senate Avenue, Indianapolis, Indiana 46204.

326 IAC 6.8-2-6

Air Pollution Control Board; 326 IAC 6.8-2-6; filed Aug 10, 2005, 1:00 p.m.: 28 IR 3508; filed Jan 23, 2008, 1:44 p.m.: 20080220-IR-326040279FRA; errata filed Feb 29, 2008, 8:54 a.m.: 20080312-IR-326040279ACA