Volkswagen Group of America, Receipt of Petition for Decision of Inconsequential Noncompliance

AGENCY:

National Highway Traffic Safety Administration (NHTSA), Department of Transportation (DOT).

ACTION:

Receipt of petition.

SUMMARY:

Volkswagen Group of America (Volkswagen), has determined that certain model year (MY) 2015-2016 Volkswagen e-Golf and Golf R passenger cars do not fully comply with paragraphs S4.3(c) and S4.3(d) of Federal Motor Vehicle Safety Standard (FMVSS) No. 110, Tire Selection and Rims and Motor Home/Recreation Vehicle Trailer Load Carrying Capacity Information for Motor Vehicles with a GVWR of 4,536 kilograms (10,000 pounds) or Less. Volkswagen filed a report dated November 25, 2015, pursuant to 49 CFR part 573, Defect and Noncompliance Responsibility and Reports. Volkswagen then petitioned NHTSA under 49 CFR part 556 requesting a decision that the subject noncompliance is inconsequential to motor vehicle safety.

DATES:

The closing date for comments on the petition is March 31, 2016.

ADDRESSES:

Interested persons are invited to submit written data, views, and arguments on this petition. Comments must refer to the docket and notice number cited at the beginning of this notice and submitted by any of the following methods:

• Mail: Send comments by mail addressed to: U.S. Department of Transportation, Docket Operations, M-30, West Building Ground Floor, Room W12-140, 1200 New Jersey Avenue SE., Washington, DC 20590.
• Hand Deliver: Deliver comments by hand to: U.S. Department of Transportation, Docket Operations, M-30, West Building Ground Floor, Room W12-140, 1200 New Jersey Avenue SE., Washington, DC 20590. The Docket Section is open on weekdays from 10 a.m. to 5 p.m. except Federal Holidays.
• Electronically: Submit comments electronically by: Logging onto the Federal Docket Management System (FDMS) Web site at http://www.regulations.gov/. Follow the online instructions for submitting comments. Comments may also be faxed to (202) 493-2251.

Comments must be written in the English language, and be no greater than 15 pages in length, although there is no limit to the length of necessary attachments to the comments. If comments are submitted in hard copy form, please ensure that two copies are provided. If you wish to receive confirmation that your comments were received, please enclose a stamped, self-addressed postcard with the comments. Note that all comments received will be posted without change to http://www.regulations.gov , including any personal information provided.

Documents submitted to a docket may be viewed by anyone at the address and times given above. The documents may also be viewed on the Internet at http://www.regulations.gov by following the online instructions for accessing the dockets. DOT's complete Privacy Act Statement is available for review in the Federal Register published on April 11, 2000, (65 FR 19477-78).

The petition, supporting materials, and all comments received before the close of business on the closing date indicated above will be filed and will be considered. All comments and supporting materials received after the closing date will also be filed and will be considered to the extent possible. When the petition is granted or denied, notice of the decision will be published in the Federal Register pursuant to the authority indicated below.

SUPPLEMENTARY INFORMATION:

I. Overview: Pursuant to 49 U.S.C. 30118(d) and 30120(h) (see implementing rule at 49 CFR part 556), Volkswagen submitted a petition for an exemption from the notification and remedy requirements of 49 U.S.C. Chapter 301 on the basis that this noncompliance is inconsequential to motor vehicle safety.

This notice of receipt of Volkswagen's petition is published under 49 U.S.C. 30118 and 30120 and does not represent any agency decision or other exercise of judgment concerning the merits of the petition.

II. Vehicles Involved: Affected are approximately 4,965 MY 2015-2016 Volkswagen e-Golf passenger vehicles that were manufactured between May 21, 2014 and November 14, 2015 and approximately 4,618 MY 2015-2016 Volkswagen Golf R passenger vehicles that were manufactured between October 24, 2014 and November 14, 2015.

III. Noncompliance: Volkswagen explains that the noncompliance is that the tire placard, located on the driver's side B-pillar, was misprinted and does not contain the word “none” in the area reserved for the spare tire specifications (i.e., size and pressure valves) as required by paragraphs S4.3(c) and S4.3(d) of FMVSS No. 110.

IV. Rule Text: Paragraph S4.3 of FMVSS No. 110 requires in pertinent part:

S4.3 Placard. Each vehicle, except for a trailer or incomplete vehicle, shall show the information specified in S4.3(a) through (g), and may show, at the manufacturer's option, the information specified in S4.3(h) through (i), on a placard permanently affixed to the driver's side B-pillar . . .

(c) Vehicle manufacturer's recommended cold tire inflation pressure for front, rear and spare tires, subject to the limitations of S4.3.4. For full size spare tires, the statement “see above” may, at the manufacturer's option replace manufacturer's recommended cold tire inflation pressure. If no spare tire is provided, the word “none” must replace the manufacturer's recommended cold tire inflation pressure.

(d) Tire size designation, indicated by the headings “size” or “original tire size” or “original size,” and “spare tire” or “spare,” for the tires installed at the time of the first purchase for purposes other than resale. For full size spare tires, the statement “see above” may, at the manufacturer's option replace the tire size designation. If no spare tire is provided, the word “none” must replace the tire size Designation;

V. Summary of Volkswagen's Petition: Volkswagen believes that the subject noncompliance is inconsequential to motor vehicle safety because the misprinted information on the tire placard is applicable to a component (spare tire) that was not provided with the subject vehicles. Volkswagen also stated that there is no effect on drivability, vehicle safety or tire wear.

Volkswagen also stated that they are not aware of any field or customer complaints related to the subject noncompliance.

Volkswagen additionally informed NHTSA that it has corrected the noncompliance so that all production of the subject vehicle models on and after November 14, 2015 will fully comply with FMVSS No. 110.

In summation, Volkswagen believes that the described noncompliances of the subject vehicles is inconsequential to motor vehicle safety, and that its petition, to exempt Volkswagen from providing recall notification of noncompliances as required by 49 U.S.C. 30118 and remedying the recall noncompliance as required by 49 U.S.C. 30120 should be granted.

NHTSA notes that the statutory provisions (49 U.S.C. 30118(d) and 30120(h)) that permit manufacturers to file petitions for a determination of inconsequentiality allow NHTSA to exempt manufacturers only from the duties found in sections 30118 and 30120, respectively, to notify owners, purchasers, and dealers of a defect or noncompliance and to remedy the defect or noncompliance. Therefore, any decision on this petition only applies to the subject vehicles that Volkswagen no longer controlled at the time it determined that the noncompliance existed. However, any decision on this petition does not relieve vehicle distributors and dealers of the prohibitions on the sale, offer for sale, or introduction or delivery for introduction into interstate commerce of the noncompliant vehicles under their control after Volkswagen notified them that the subject noncompliance existed.

Authority: 49 U.S.C. 30118, 30120: delegations of authority at 49 CFR 1.95 and 501.8.