Opinion
Docket No. 57139.
Argued May 4, 1976 (Calendar No. 7).
Decided February 14, 1977. Rehearing granted 400 Mich. 984.
Abood, Abood Abood, P.C. (by Richard J. Abood and William E. Rheaume) for plaintiffs.
Cholette, Perkins Buchanan (by Grant J. Gruel and Kenneth L. Block) for defendant General Motors Corporation.
An allegedly defective automobile wheel assembly provides yet another occasion to examine Michigan products liability law. The specific question is whether the trial court correctly awarded defendant General Motors a directed verdict because no proofs were introduced which would indicate or permit the reasonable inference that the right front ball joint assembly was defectively designed, constructed with defective material, or improperly assembled. The Court of Appeals agreed with the trial court's decision, and we likewise believe that a directed verdict was properly awarded for defendants.
On May 28, 1971, Ernest T. Holloway was traveling between 50 and 55 miles an hour on Nixon Road in Eaton County, when he lost control of his 1967 Chevrolet automobile and struck a telephone pole. Holloway was killed and his minor daughter, Brenda, sustained multiple injuries. The accident was allegedly caused by a defective ball joint assembly in the right front wheel, which broke while traveling over chuckholes in the road.
Plaintiff, surviving wife Sharon, filed suit for damages against General Motors, Eaton County, and the Eaton County Road Commission. At the close of trial, a verdict of no cause of action was entered in favor of Eaton County and the commission. Defendant General Motors was awarded a directed verdict because no proofs were introduced to permit the inference of a breach of warranty due to a failure of the vehicle's suspension system when it had performed more than four years covering some 47,000 miles without evidence of a part failure.
Plaintiff appealed, and Judge O'HARA, writing for the majority below, viewed the Court of Appeals position as having to choose between two mutually exclusive rules of law as set forth in Piercefield v Remington Arms Co, Inc, 375 Mich. 85; 133 N.W.2d 129 (1965), and Bronson v J L Hudson Co, 376 Mich. 98; 135 N.W.2d 388 (1965). Piercefield required that a plaintiff must "prove a defect attributable to the manufacturer and causal connection between that defect and the injury or damage of which he complains". The rule in Bronson, gleaned from the passage quoted in the margin, is that even in the absence of competent direct evidence, it is error to conclude as a matter of law that a prima facie case cannot be established where the evidence, viewed in the light most favorable to plaintiff, permits reasonable minds to differ as to the legitimate inferences that might be drawn from the proofs submitted. The Court elected to follow Piercefield which requires "more than accident and injury to constitute a jury-submissible question of breach of implied warranty of fitness for the purpose intended". Unable to find any testimony which would indicate defective design or material, and in the absence of any evidence suggesting improper assembly, the Court affirmed the trial judge's award of the directed verdict for defendant.
375 Mich. 98-99.
"Upon the record made, was defendant entitled to a directed verdict? In Weisenberg v Village of Beulah, 352 Mich. 172, 184 [ 89 N.W.2d 490 (1958)], this Court said: `that the testimony and all legitimate inferences that may be drawn therefrom must be viewed in the light most favorable to the plaintiff in determining whether he has established a prima facie case when weighed against defendant's motion for a peremptory verdict in his favor at the close of plaintiff's proofs.'
"In the instant case, there was no competent direct proof of what specific irritant, if any, was present in the slip cloth. Upon favorable view, did the facts, along with legitimate inferences to be drawn therefrom, constitute a prima facie case sufficient in law to prevail against defendant's motion for directed verdict? More specifically, was there evidence from which it might be legitimately inferred that an irritant was present in the cloth at time of purchase, which irritant was a proximate cause of injury?" 376 Mich. 98, 101-102.
The dissenting opinion, however, viewed the two cases as being consistent. Piercefield is interpreted as detailing what a plaintiff is required to prove in a products liability claim, "namely, `a defect attributable to the manufacturer and causal connection between that defect and the injury or damage'". Bronson is seen as expanding upon this rule by "explaining how a plaintiff could prove the claim, by the introduction of direct proof and through the inferences which the jury might draw from that proof". The dissent concluded that sufficient credible evidence existed which would permit a jury to infer the existence of a defect.
While we share the concern expressed by Judge O'HARA, that the absence of clearly defined rules to be applied in product liability cases may lead to "ad hoc disposition, case by case", the alternative need not be a choice between what are viewed as two conflicting lines of authority. This Court recently stated in Caldwell v Fox, 394 Mich. 401, 410; 231 N.W.2d 46 (1975), and Kupkowski v Avis Ford, Inc, 395 Mich. 155; 235 N.W.2d 324 (1975), that in order to prevail in either a breach of warranty or negligence action a plaintiff must "prove a defect attributable to the manufacturer and causal connection between that defect and the injury or damage of which he complains". Both direct and circumstantial evidence may be introduced to prove such a defect. To the extent that the Court of Appeals opinion is interpreted as limiting evidence considered in products liability cases to direct proofs, we wish to make clear that the existence of a defective condition may be inferred from circumstantial evidence alone. Caldwell v Fox, supra; Schedlbauer v Chris-Craft Corp, 381 Mich. 217; 160 N.W.2d 889 (1968); Bronson v J L Hudson Co, supra. In the instant case there was no demonstrable malfunction which would have provided unequivocal and direct evidence that a defect existed in the right front ball joint assembly when the vehicle left control of the manufacturer, defendant General Motors. Therefore, we must review the circumstantial evidence which plaintiff believes will permit a reasonable inference that such a defect existed.
This point is well stated in Snider v Bob Thibodeau Ford, Inc, 42 Mich. App. 708, 713; 202 N.W.2d 727, 730 (1972), by then-Judge LEVIN:
"A demonstrable malfunction is generally clear evidence of a defect, but the legal conclusion that a product is defective may follow from circumstantial evidence without the need physically to exhibit the loose bolt or structural weakness."
Plaintiff's brief states that more than ample proof has been presented at trial to show that a failure of the right front ball joint occurred on the roadway which caused the vehicle to slide to the right, leave the road, and collide with a telephone pole. In support of this position, plaintiff offered testimony from an expert witness that this type of failure is not expected "from driving a car at 55 or 50 miles an hour over a rough road". The witness is an independent consulting physicist who stated that in his opinion the failure occurred on the roadway because of the hazardous condition of the road which resulted in the decedent's inability to control the vehicle. Upon further cross-examination, he testified that his expertise was not that of a qualified metallurgist and therefore he could not testify as to stress and design analysis, material strength, or any other aspect of metallurgy that would explain the breakage in the ball joint. The testimony of this witness, however, assumes that which is sought to be proved, and does not address the question of whether a defect was present in the ball joint assembly which would cause such a failure to occur.
Plaintiff further directs our attention to the absence of testimony indicating that (1) the vehicle was improperly maintained and (2) failures of this type are expected to occur in vehicles after they have been operated for a four-year period. Apparently we are asked to conclude from this that the ball joint failure could be attributed to defective material or design, or improper assembly. In Kupkowski v Avis Ford, Inc, supra, we rejected plaintiff's attempt to prove a braking system defective by the absence of evidence indicating repair or replacement of the brake parts. In that case, lack of repair or maintenance records invited the inference that none had been performed and, by further inference, this caused the alleged defect that existed in the vehicle's braking system to remain undiscovered and, therefore, unrepaired. The latter inference was ruled as impermissible conjecture not properly based upon a known positive fact. See, also, Kaminski v Grand Trunk W R Co, 347 Mich. 417; 79 N.W.2d 899 (1956).
The difficulty in asserting lack of evidence as a basis for reasonably inferring the existence of a defective automobile part is readily apparent. Because no testimony was introduced that the vehicle was improperly maintained, the jury is asked to conclude that the decedent's loss of control could be attributable to a defective ball joint assembly. Reviewing the theories advanced in Kupkowski and the instant case, we are urged to conclude that either an alleged defect would have been discoverable or all other causes of the failure were eliminated, depending upon whether testimony of proper or improper maintenance is absent from the record. In either case the inferences drawn are improper and are in direct contradiction of the established rule that the burden is upon the plaintiff to prove, not the defendant to disprove, the existence of a defect and its causal connection with the injury or damage suffered. Piercefield v Remington Arms Co, supra; Kupkowski v Avis Ford, Inc, supra.
It is agreed that if a question of fact exists upon which reasonable persons may differ, the trial judge should not direct a verdict for defendant. Once granted, however, to determine on review whether such verdict is proper, we must accord plaintiff the benefit of viewing the testimony and all legitimate inferences that may be drawn therefrom in a light most favorable to the plaintiff. Caldwell v Fox, supra. We have considered other evidence in the record which might be helpful to plaintiff in establishing a prima facie case, yet remain convinced that the trial court properly directed a verdict for defendant.
A nearby resident testified that she heard a "loud bang" from inside her home and, after walking to her doorway, saw the Holloway vehicle, airborne, striking a telephone pole. An investigating officer testified that he observed marks with a "scuffing effect" on the highway. He further observed that the "A" frame for the right front axle was broken. Testimony from two others was received to the effect that the chuckholes 4 to 6 inches deep and 12 to 8 inches wide with some "pretty sharp corners" were in the roadway. Plaintiff's expert witness testified that the markings on the road and the sound heard by the neighbor indicate that the separation of the lower control arm occurred while the car was on the highway and that it was quite probable that the separation was caused by the holes in the road.
This case differs from earlier decisions in significant respects. Unlike Caldwell, the vehicle involved in the instant case is a four-year-old, third-owner, used car which had been driven 47,000 miles. It is obvious that the longer a product has been in use the more difficult it is to prove that a defect existed while in the control of the manufacturer. We recently expressed a particular unwillingness to extend recovery in cases where the product "requires periodic maintenance, where reasonable wear is a natural consequence of normal usage, and the product has provided defect-free serviceability for a reasonable period of time". Unlike Snider, there was no evidence of prior incidents involving the malfunction of any part of the steering or suspension systems. And, unlike Bronson, plaintiff was unable to effectively eliminate any other factors or circumstances which could have been responsible for the failure. We conclude that the evidence presented permits no reasonable inference that a defective ball joint assembly existed when the vehicle left the control of defendant.
Kupkowski v Avis Ford, Inc, supra, 166.
We quote the summation of this case as set forth by the court below:
"A car left the road. A man was regrettably killed and a child injured. A piece of machinery was found broken. No one qualified to say so testimonially claimed it was too weak, too long, too short, or too anything. Neither did anyone say it was not designed correctly, the metal too light or that it was not too anything. Under the circumstances we feel obligated to affirm the trial judge." 60 Mich. App. 208, 216.
Considering both the direct and circumstantial evidence and the inferences to be drawn therefrom, we also feel obliged to agree with the trial judge.
Affirmed. Costs to appellee.
COLEMAN AND RYAN, JJ., concurred with FITZGERALD, J.
Ernest Holloway was killed and his daughter was seriously injured when his automobile struck a utility pole. Holloway had been driving at a speed of approximately 50 to 55 miles per hour along a gravel road when the car left the road. The car was four years old and had been driven over 47,000 miles.
The Holloways commenced this product liability action against the manufacturer claiming that the cause of the accident was a defective ball joint in the right front wheel assembly which broke as the car traveled over chuckholes in the road.
Plaintiffs' theories were breach of express and implied warranties, improper design and negligence in failing to inspect the vehicle.
The complaint also alleged negligent maintenance of county roads and failure to eliminate and warn of dangerous conditions against the Eaton County Road Commission and Eaton County, issues not before this Court on this appeal.
The issue is whether the trial judge erred in directing a verdict for defendant on the ground that there was insufficient evidence of a manufacturing defect in the wheel assembly to establish a prima facie case of product liability.
All agree that circumstantial as well as direct evidence may be considered in determining whether there is a prima facie case. We would reverse because there was sufficient evidence, albeit largely circumstantial, of product defect to require submission to the jury.
I
The ball joint assembly was broken when examined after the accident. The principal factual dispute was whether it broke before the car left the road, causing the accident, or when the car struck the utility pole.
The testimony of four witnesses tended to show that the wheel assembly broke before the car left the road.
Police Officer Simpson testified that tire marks on the road indicated that the right front tire had been scraping sideways before it left the road, and in his opinion the wheel assembly broke before the car left the road.
Deputy Smith similarly testified that three of the tires left tread marks and the right front tire track was much wider. He also concluded that the wheel assembly broke while the car was on the road.
A Mrs. Foster, an eyewitness, testified that she had heard a loud bang before seeing the car leave the road.
Plaintiffs' expert, Joseph Harris, concluded on the basis of the tire tracks and the bang heard by the witness that the break occurred while the car was on the road and that the bumpy road was a likely cause of the breakage. He said that the bank "marked that failure [of the wheel assembly] which is evidence[d] by those tire tracks, which then resulted in the car going off to the right".
While Harris did not testify on stress and design analysis, material strength, or other aspects of metallurgy, he was qualified as an expert in the investigation, determination and reconstruction of the causes of collisions. The judge did not err in allowing Harris to express his opinion regarding the cause of the accident.
II
Although generally the plaintiff in a product liability case will offer expert opinion testimony that, on examination of the product, it was found to be defective, such testimony is not essential. "[A] product can be proved defective by drawing reasonable inferences from circumstantial evidence without specifically proving the existence of a demonstrable defect." Kupkowski v Avis Ford, Inc, 395 Mich. 155, 166; 235 N.W.2d 324 (1975).
See MacDougall v Ford Motor Co, 214 Pa. Super. 384, 391; 257 A.2d 676, 679 (1969); Kridler v Ford Motor Co, 422 F.2d 1182, 1186 (CA 3, 1970).
Similarly, see Schedlbauer v Chris-Craft Corp, 381 Mich. 217; 160 N.W.2d 889 (1968), and Bronson v J L Hudson Co, 376 Mich. 98; 135 N.W.2d 388 (1965).
Evidence of sudden, uncontrollable failure in the steering or braking mechanism, along with physical evidence that the damage is not attributable to the impact, may permit an inference that there was a defect and that it existed before the vehicle left the pavement.
See Necaise v Chrysler Corp, 335 F.2d 562, 568 (CA 5, 1964); see also Nelson v Ford Motor Co, 469 F.2d 261, 262-263 (CA 5, 1972).
In Hunter v Ford Motor Co, 37 App. Div. 2d 335, 337; 325 N.Y.S.2d 469, 471 (1971), the driver heard a sudden noise and the left section of his truck dropped to the road. A state trooper testified that his on-the-scene investigation disclosed gouges in the road leading toward the wrecked vehicle. Although plaintiff's expert witness found no specific defect in the axle and was unable to state precisely the cause of the break, he said that the axle had undergone a sudden "one-step" failure, that a properly designed and manufactured axle should not ordinarily break in this way, and that in his opinion it was defective. A verdict for plaintiff was affirmed.
To establish a prima facie case "`the defect need not be apparent at the time the product left the factory, but may be merely a latent defect or hidden defect which later arises and causes damage'". Codling v Paglia, 32 N.Y.2d 330, 337-338; 298 N.E.2d 622, 625 (1973). Although the occurrence of an accident does not prove that the cause was a manufacturing defect, the manufacturer's responsibility for the defect may be inferred from evidence of malfunction and other accompanying circumstances. Such evidence may be sufficient to overcome evidence tending to support defendant's theory that the damage was the result rather than the cause of the collision.
The court held that the manufacturer of a defective steering mechanism may be liable for breach of implied warranty to an "innocent bystander".
Prosser, Torts (4th ed), § 103, p 673. See MacDougall v Ford Motor Co, supra, pp 390-391 (new car steering mechanism); Kridler v Ford Motor Co, supra, p 1185 (same).
See also Codling v Paglia, 32 N.Y.2d 330, 337-338; 298 N.E.2d 622, 625 (1973); Markel v Spencer, 5 App. Div. 2d 400, 404; 171 N.Y.S.2d 770, 775 (1958); Redman v Ford Motor Co, 253 S.C. 266; 170 S.E.2d 207 (1969).
Jenkins v General Motors Corp, 446 F.2d 377 (CA 5, 1971); Redman v Ford Motor Co, supra; Rosin v International Harvester Co, 262 Minn. 445; 115 N.W.2d 50 (1962).
Directed verdicts for defendant were reversed in Wylie v Ford Motor Co, 502 F.2d 1292 (CA 10, 1974), and Rosin v International Harvester Co, supra.
Although many cases in which recovery has been allowed involve relatively new vehicles where the inference that the defect existed at the time the vehicle left the factory is especially compelling, the age and mileage of the vehicle go to the strength of that inference and are therefore generally questions for the jury. The inference that the defect was attributable to the manufacturer has been held to be reasonable where the vehicle was driven 14,000, 18,000 or 44,000 miles.
See Kanatser v Chrysler Corp, 199 F.2d 610, 617 (CA 10, 1952), cert den 344 U.S. 921; 73 S Ct 388; 97 L Ed 710 (1953); Hupp Motor Car Corp v Wadsworth, 113 F.2d 827, 828, 829 (CA 6, 1940); Jenkins v General Motors Corp, supra; Hunter v Ford Motor Co, 37 App. Div. 2d 335; 325 N.Y.S.2d 469 (1971); Redman v Ford Motor Co, supra; General Motors Corp v Johnson, 137 F.2d 320 (CA 4, 1943); Ford Motor Co v Kuhbacher, 518 P.2d 1255 (Wyo, 1974).
See Wylie v Ford Motor Co, supra, p 1294.
Rosin v International Harvester Co, supra.
Parker v Ford Motor Co, 296 S.W.2d 35 (Mo, 1956).
Wylie v Ford Motor Co, supra.
III
My colleague states that given the age of the vehicle, the number of miles it had been driven, and that Holloway was its third owner, the inference that there was a latent defect when the car left the factory would not be justified:
"We recently expressed a particular unwillingness to extend recovery in cases where the product `requires periodic maintenance, where reasonable wear is a natural consequence of normal usage, and the product has provided defect-free serviceability for a reasonable period of time.' [Kupkowski v Avis Ford, Inc, supra, p 166.] Unlike Snider [v Bob Thibodeau Ford, Inc, 42 Mich. App. 708; 202 N.W.2d 727 (1972)], there was no evidence of prior incidents involving the malfunction of any part of the steering or suspension systems. And, unlike Bronson [v J L Hudson Co, 376 Mich. 98; 135 N.W.2d 388 (1965)], plaintiff was unable to effectively eliminate any other factors or circumstances which could have been responsible for the failure. We conclude that the evidence presented permits no reasonable inference that a defective ball joint assembly existed when the vehicle left the control of defendant."
Kupkowski and Snider concerned brake failures. Brake systems require periodic inspection and maintenance and are expected to wear out and be replaced. In such a case regular maintenance or failure to maintain may negative an inference of manufacturing defect.
Wheel assemblies are not expected to wear out and be replaced. There was no suggestion that this assembly had been tampered with or that it is a part of the car that is expected to be or reasonably should be inspected on a periodic basis.
See Markel v Spencer, supra, where a prima facie case was made in part by evidence which tended to exclude tampering with the mechanism or intervening accident.
While it may be necessary in some cases for a plaintiff to introduce evidence of proper maintenance to support an inference that the defect occurred before the product left the factory, where the defect alleged is latent in the very structure of the vehicle and may not in ordinary circumstances be discovered during routine maintenance, evidence of proper maintenance is not required.
Although "reasonable wear is a natural consequence of normal usage", it is not an adequate response to say that the vehicle is four years old, had been driven 47,000 miles and has had three owners. Automobiles are manufactured and sold for use in excess of 50,000 miles. The consumer may justifiably rely on the basic integrity of the product. A sudden failure of the wheel assembly is likely to cause death or serious bodily injury. The industry cannot properly expect that when the warranty period runs out the consumer will either junk the automobile or have it disassembled, inspected for metal fatigue or defect and rebuilt part-by-part, or be deemed to have assumed the risk of latent and non-discernible structural defects.
This is not to say that all parts of an automobile can be expected to function indefinitely and flawlessly without maintenance for the life of the vehicle. It is to say that the manufacturer who alone is in a position to guard against the risk is subject to liability for a life-threatening latent structural defect which ticks away like a time bomb with every mile driven.
Triplett v American Creosote Works, Inc, 251 Miss. 727, 735; 171 So.2d 342, 346 (1965); Jakubowski v Minnesota Mining Manufacturing Corp, 42 N.J. 177, 184; 199 A.2d 826, 830-831 (1964); Gomez v E W Bliss Co, 27 Misc.2d 649, 651; 211 N.Y.S.2d 246, 248 (1961).
While prior malfunction of a brake system may indicate a manufacturing defect, the absence of prior malfunction does not negative the existence of a latent structural defect. A defective brake system may function intermittently; it is the nature of a wheel assembly failure that there are no "prior incidents".
Although the strength of an inference that the accident was caused by a manufacturing defect depends on the plausibility of competing explanations for the accident, plaintiffs did not have the burden of proving that the accident could only be attributable to a manufacturing defect or "of effectively eliminating any other factors or circumstances which could have been responsible for the failure". It was enough that they indicated "a logical sequence of cause and effect * * * notwithstanding the existence of other plausible theories with or without support in the evidence". Schedlbauer v Chris-Craft Corp, 381 Mich. 217, 220, fn 1; 160 N.W.2d 889 (1968). They were "not required to offer evidence which positively exclude[s] every other possible cause of the accident". Swensson v New York, Albany Despatch Co, 309 N.Y. 497, 502; 131 N.E.2d 902, 904 (1956).
The Court reaffirmed the rule adopted in Kaminski v Grand Trunk W R Co, 347 Mich. 417, 422; 79 N.W.2d 899 (1956).
Defendant's theory was that the cause of the accident was Holloway's loss of control of the car and that the wheel assembly broke on impact. Defendant suggested no other explanation for the breakage. Plaintiffs negatived that theory with evidence tending to show that the break occurred before the car left the road. Defendant made no claim that such a break "is a natural consequence of normal usage" or that it was attributable to improper maintenance.
In sum, the jury could reasonably infer that the wheel assembly broke before the car left the road. A defect in the wheel assembly involves the basic structural integrity of the vehicle and may not be discoverable during periodic maintenance. There is no suggestion that this wheel assembly had been tampered with or improperly maintained. A jury could reasonably conclude that there was a defect and that it was latent until the wheel assembly broke without warning causing the accident or, alternatively, it could accept the manufacturer's explanation that it broke when the vehicle struck the utility pole and did not cause the accident.
Plaintiffs sustained their burden by introducing evidence from which the jury could reasonably infer that the accident was caused by a manufacturing defect, even though that was not the only inference that might have been drawn. "As on other issues in civil actions, [in a product liability case] it is enough that he makes out a preponderance of probability. It is enough that the court cannot say that reasonable men on the jury could not find it more likely than not that the fact is true." Prosser, Torts (4th ed), § 103, p 673.
The trial judge erred in directing a verdict. We would reverse and remand for a new trial.
KAVANAGH, C.J., and WILLIAMS, J., concurred with LEVIN, J.
BLAIR MOODY, JR., J., took no part in the decision of this case.